N819NK

Part: SOLENOID — STUCK (COCKPIT CHIME)

LP 0264638; ON PRE-FLIGHT FOUND FLIGHT DECK AUDIO ALERTING CHIME INOPERATIVE. FOUND COCKPIT CHIME BELL SOLENOID STUCK AND SHORTING TO GROUND, REMOVED AND REPLACED COCKPIT CHIME BELL. AIRCRAFT TAIL SWAP WIGH N812NK.

Part: SLIDE — LOOSE (L2 DOOR)

SLIDE PACK ON L2 DOOR LOOSE FROM DOOR. RESECURED SLIDE PACK ON L2 DOOR IAW MM 25-62-00.

Part: SLIDE — DISLODGED (L2 DOOR)

LGA - FLT 9950 - L2 DOOR SLIDE FALLING OUT. FOUND L2 DOOR SLIDE PACK FALLING OUT RESECURED PACK. (M)

Part: SLIDE — DISLODGED (L2 DOOR)

FLT 642 - TPA - FOUND L2 SLIDE PACK FALLING OFF. RESECURED L2 SLIDE PACK AND COVER. (M)

Part: SLIDE — MISINSTALLED (L1 DOOR)

RSW - FLT 670 - FOUND FORWARD SLIDE IN L1 DOOR FOUND HOLDING PINS NOT CORRECT. REMOVED AND REPLACED FORWARD L1 EVAC SLIDE. (M)

Part: SKIN — DEBONDED (SPOILER)

DTW - FOUND RIGHT INBOARD FLIGHT SPOILER HAS PREVIOUS REPAIR DISBONDED. REMOVED AND REPLACED RIGHT INBOARD FLIGHT SPOILER. OPS CHECK GOOD. (M)

Part: GEARBOX — CRACKED (NR 2)

ACY - FOUND FRONT ACCESSORY DRIVE GROUP COVER CRACKED AT 7 O'CLOCK POSITION. REMOVED AND REPLACED FRONT ACCESSORY, N-1 TACH, GEAR BOX. (M)

Part: PIN — OUT OF POSITION (EVAC SLIDE)

CHECK L1 DOOR SLIDE PACK. FOUND LANYARD AND UNFURLING PINS OUT. REMOVED SLIDE FROM DOOR AND REINSTALLED UNFURLING PINS. REINSTALLED PACK BACK ON L1 DOOR AND LANYARD. NO FURTHER DEFECTS NOTED.

Part: CABLE — MISROUTED (EVAC SLIDE)

DTW - FLT 955 - FOUND L-2 DOOR ESCAPE SLIDE CABLE TO GIRT BAR INCORRECTLY ATTACHED. REPOSITIONED CABLE. (M)

Part: SLIDE — OUT OF POSITION (L2 DOOR)

ACY - FLT 1141 - AFT SLIDE PACK AT GALLEY L-2 DOOR FELL OFF. REINSTALLED SLIDE PACK AND COVER. NO DEFECTS NOTED. (M)

Part: HOLDER — BROKEN (FLASHLIGHT)

DTW - FOUND FORWARD LEFT EMERGENCY FLASHLIGHT HOLDER IS BROKEN. REMOVED AND REPLACED FORWARD LEFT EMERGENCY FLASHLIGHT HOLDER. (M)

Part: VANE — DENTED (TE FLAPS)

FTW - FOUND TWO DENTS ON UPPER OF INBOARD RIGHT FLAP DENTS ARE ON VANE ASSEMBLY 31 INCHES FROM INBOARD EDGE. DENT IS OUT OF LIMITS. ON FURTHER INVESTIGATION FOUND EXTERNAL DOUBLER DISBONDED, SKIN DELAMINATION. REPAIRED DENTS. REPAIRED DOUBLER AND DELAMINATED AREA. (M)

Part: FLOORBOARD — CRACKED (FUSELAGE)

FTW - FOUND CORROSION ON FLOORBOARD STATION 826 TO 1003 RBL 44 TO 54. UPON FURTHER INVESTIGATION CRACK FOUND AROUND SCREW HOLE. FABRICATED DOUBLER AND REMOVED CRACK. INSTALLED DOUBLER AND FILLER. (M)

Part: CUSP WEB — CORRODED (FUSELAGE)

FTW - FOUND AFT PIT STATION 1193-1212 STRINGER 18L WEB CORRODED. REMOVED WEB FROM STATION 1174 TO STATION 1250. FABRICATED NEW WEB AND DOUBLER TWO MATERIAL LOSS ON FRAME FITTING OUT OF LIMITS. REMOVED FRAME FITTING. LOCATED AND DRILLED NEW FRAME FITTING. INSTALLED NEW FRAME FITTING. INSTALLED WEB. (M)

Part: SLIDE — UNSECURE (L1 DOOR)

FTW - FOUND L1 DOOR SLIDE IS COMING UNPACKED. REPLACED L1 DOOR SLIDE. (M)

Part: FLOOR PANEL — DAMAGED (FUSELAGE)

FTW - FOUND FLOOR PANEL STATION 320-370 EDGES SPLIT-CRUSHED. FABRICATED NEW FLOOR PANEL. (M)

Part: FLOORBOARD — PEELING (FUSELAGE)

FTW - FOUND CABIN FLOORBOARD RIGHT AFT STATION 1307 PEELING FIBERGLASS. REQUIRES EDGE FILLER. FABRICATED NEW CABIN FLOORBOARD. (M)

Part: FLOORBOARD — DELAMINATED (FUSELAGE)

FTW - FOUND CABIN FLOORBOARD STATION 1200, RBL 24-44 PEELING FIBERGLASS 349. REQUIRES EDGE FILLER. FABRICATED NEW CABIN FLOORBOARD. (M)

Part: LIGHT — BROKEN (G4 GALLEY)

FTW - FOUND G4 GALLEY HAS BROKEN EXIT LIGHT. REMOVED OLD BROKEN EXIT LIGHT. INSTALLED NEW EXIT LIGHT. (M)

Part: FLOORBOARD — DELAMINATED (FUSELAGE)

FTW - FOUND BROKEN INSERT AND DELAMINATION, CABIN FLOORBOARD FS 1140. FABRICATED NEW FLOORBOARD. (M)

Part: FLOOR PANEL — DAMAGED (FUSELAGE)

FTW - FOUND FLOOR PANEL METAL EDGES BENT, CRACKED, WORN THROUGH. NO EDGE SEAL. FABRICATED NEW FLOOR PANEL. (M)

Part: FLOOR PANEL — DETERIORATED (FUSELAGE)

FTW - FOUND FLOOR PANEL STATION 1079-1155 DETERIORATING. FABRICATED NEW FLOOR PANEL. (M)

Part: FLOOR PANEL — DELAMINATED (FUSELAGE)

FTW - FOUND FLOOR PANEL STATION 1150-1250 LEFT, MISSING BROKEN INSERTS NO EDGE SEAL. UPON FURTHER EVALUATION FOUND PANEL AT STATION 1150-1250 TO BE DELAMINATED. FABRICATED NEW FLOOR PANEL. (M)

Part: FLOOR PANEL — CORRODED (FS 1174)

FTW - FOUND FLOOR PANEL FS 1174 RBL 24-44 CORRODED AND TOP PRIMER REQ'D. FABRICATED FLOOR PANEL. (M)

Part: FLOOR PANEL — CRACKED (FUSELAGE)

FTW - FOUND FLOOR PANEL HAS CORROSION AT EDGES AND FAST HOLES, END OF STIFFENER CRACKED. STOP DRILLED CRACK. FABRICATED REPAIR. INSTALLED REPAIR. (M)

Part: FLOOR PANEL — DETERIORATED (FUSELAGE)

FTW - FOUND FLOOR PANEL STATION 1225 LEFT DETERIORATING NO EDGE SEAL. FABRICATED NEW FLOOR PANEL. (M)

Part: WEB — CRACKED (FUSELAGE)

FTW - FOUND CRACK IN SUBFLOOR PAX CABIN ENTRY AT FS 161, 24 INCHES LBL. REMOVED DAMAGED SUBFLOOR AREAS. FABRICATED REPAIR DOUBLER. INSTALLED REPAIR DOUBLER. (M)

Part: SUPPORT — CRACKED (FLOOR PANEL)

FTW - FOUND CABIN FLOOR PANEL STATION 1174-1250 HAS CRACKED FLOOR SUPPORT. REPAIRED CRACKED FLOOR SUPPORT ON FLOOR PANEL. (M)

Part: FLOORBOARD — DELAMINATED (FUSELAGE)

FTW - FOUND LEFT FLOORBOARD STATION 1136-1193 DELAMINATED AND INSERTS CORRODED. FABRICATED NEW LEFT FLOORBOARD. (M)

Part: FITTING — CRACKED (LT WING TE FLAP)

FTW - FOUND LEFT WING INBAORD FLAP INBOARD ACTUATOR ATTACHED FITTING CRACKED. REMOVED LEFT INBOARD FLAP INBOARD ACTUATOR ATTACH FITTING. LOCATED AND DRILLED ATTACH FITTING. INSTALLED LEFT INBOARD FLAP INBOARD ACTUATOR ATTACH FITTING. (M)

Part: PAN — CORRODED (FUSELAGE)

FTW - FOUND FORWARD CARGO DOOR PAN HAS CORROSION AND CORRODED FASTENERS STATION 370-427 AND IS GOUGED AT STATION 379, DOOR STOP FITTINGS. CUT OUT DAMAGED. FABRICATED 04 EACH ANGLES. LOCATED AND DRILLED HOLES IN NEW FORWARD CARGO DOOR PAN. INSTALLED NEW FORWARD CARGO DOOR PAN. (M)

Part: SEAT TRACK — CORRODED (FUSELAGE)

FTW - FOUND FORWARD CABIN STATION 200 TO STATION 218 RIGHT SIDE OUTBOARD SEAT TRACK CORRODED. REMOVED SEAT TRACK RIGHT OUTBOARD STATION 200-247. FABRICATED NEW SECTION OF SEAT TRACK RIGHT OUTBOARD STATION 200-247. INSTALLED NEW SEAT TRACK. (M)

Part: FLOORBOARD — CRACKED (FUSELAGE)

FTW - FOUND SCREW HEAD PULLED THROUGH FLOORBOARD STATION 250 LBL 44, AND PANEL CRACKED AT HOLE. STOP DRILLED CRACK. FABRICATED REPAIR DOUBLER. INSTALLED REPAIR DOUBLER. (M)

Part: ACCESS PANEL — CORRODED (LT WING)

FTW - FOUND LEFT WING ACCESS PANEL HAS SURFACE CORROSION AROUND FASTENERS ON EXTERIOR SIDE. REMOVED CORROSION. FABRICATED REPAIR PART. INSTALLED REPAIR PART. (M)

Part: FITTING — CORRODED (FUSELAGE)

FTW - FOUND LEFT AFT LAVATORY STATION 1322 STRINGER 18L FITTING CORRODED. REMOVED FITTING. INSTALLED NEW FITTING. (M)

Part: FLOORBOARD — DELAMINATED (FUSELAGE)

FTW - FOUND COCKPIT CENTER FLOORBOARD, BROKEN INSERTS AND SIDE DELAMINATIONS. FABRICATED NEW COCKPIT CENTER FLOORBOARD. (M)

Part: FRAME — CRACKED (FUSELAGE)

FTW - FOUND CRACKED FRAME AT FS 1338 AND LONGERON 18R. CUT OUT DAMAGED AREA. FABRICATED FRAME SECTION AND REPAIR DOUBLER. INSTALLED REPAIR PARTS. (M)

Part: FLOORBOARD — DAMAGED (FUSELAGE)

FTW - FOUND RIVETS PULLED THROUGH FLOORBOARD STATION 826 LBL 44 TO 54. UPON FURTHER INVESTIGATION FLOORBOARD STATION 826 LBL 44 TO 54 FOUND TO HAVE NUMEROUS BLOWN OUT HOLES, CRACKS, AND DELAMINATION. FABRICATED NEW FLOORBOARD. (M)

Part: DOOR FRAME — CORRODED (FUSELAGE)

FTW - FOUND AFT PRESSURE BULKHEAD DOOR JAMB THRESHOLD SEAL TORN. AFTER REMOVED TORN SEAL FOUND CORROSION. CUT OUT DAMAGED AREA AT LOWER AFT DOOR JAMB. FORMED DOUBLER. FABRICATED FILLER. INSTALLED DOUBLER AND FILLER. (M)

Part: FLOORBOARD — DELAMINATED (FUSELAGE)

FTW - FOUND CABIN FLOORBOARD LEFT AFT FS 1257 SURFACE DELAMINATED MISSING INSERT. FABRICATED NEW CABIN FLOORBOARD. (M)

Part: FITTING — CORRODED (FUSELAGE)

FTW - FOUND RIGHT AFT LAVATORY STATION 1322 STRINGER 18R FITTING CORRODED. REMOVED CORRODED FITTING. LOCATED, DRILLED AND INSTALLED NEW FITTING. (M)

Part: FLOOR PANEL — CORRODED (FUSELAGE)

FTW - FLOOR PANEL UNDER F/O SEAT CORROSION AND GOUGE IN UPPER SURFACE. BROKEN TRIM SUPPORT. DISBONDED INNER SIDE STRIPS. FABRICATED NEW FLOOR PANEL. (M)

Part: ANGLE — CORRODED (FUSELAGE)

FTW - FOUND RIGHT PASSENGER CABIN CUSP PLATE CORRODED AT STATION 207. CUT OUT CUSP ANGLE SECTION. FABRICATED 19 REPAIR ANGLE. FABRICATED 1 REPAIR CUSP ANGLE. INSTALLED REPAIR CUSP ANGLE AND 19 SPLICE ANGLE. (M)

Part: FLOORBOARD — CRACKED (FUSELAGE)

FTW - FOUND CABIN FLOORBOARD FORWARD LAVATORY STATION 200-256 CRACKED IN SEVERAL AREAS. COMPOSITE SUPPORT CRACKED ON AFT END. REPAIRED CABIN FLOORBOARD. (M)

Part: FLOORBEAM — CORRODED (FUSELAGE)

FTW - FOUND FORWARD CABIN CORRODED AT FLOORBEAM STATION 200 LBL 44 INCHES TO LBL 55 INCHES. NO MATERIAL LOSS AT FLOORBEAM. MATERIAL ID TAB END. FABRICATED NEW TAB. INSTALLED NEW TAB END. (M)

Part: FLOORBOARD — DAMAGED (FS)

FTW - FOUND CABIN FLOORBOARD, RIGHT STATION 767-787 HAS MISSING EDGE FILLER, DAMAGED INSERTS, PEELING FIBERGLASS. FABRICATED NEW CABIN FLOORBOARD. (M)

Part: PAN — CRACKED (CARGO DOOR)

FTW - FOUND MID PIT DOOR FORWARD LOWER DOOR PAN AND ATTACH FITTING CRACKED AT DOOR STOP. REMOVED CRACKED FITTING. LOCATED AND DRILLED NEW FITTING. INSTALLED FITTINGS. REMOVED CRACKED T-ANGLE. STOP DRILLED CRACKED PAN 4 PLACES. FABRICATED TWO EACH -5 DOUBLERS. FABRICATED T-ANGLE. INSTALLED T-ANGLE. INSTALLED REPAIR DOUBLERS. (M)

Part: SKIN — DELAMINATED (FLIGHT SPOILER)

RT WING INBOARD FLIGHT SPOILER DELAMINATED. REPAIRED DELAMINATED AREA. (M)

Part: FLOORBEAM — CORRODED (FUSELAGE)

FTW - FOUND FORWARD CABIN STATION 218 LBL 13 INCHES RBL 13 INCHES FLOORBEAM CORRODED TWO FROZEN SCREWS. REMOVED FLOORBEAM. DRILLED AND LOCATED HOLES. INSTALLED NEW FLOOR SUPPORT. (M)

Part: FLOORBEAM — CORRODED (FUSELAGE)

FTW - FOUND FORWARD CABIN STATION 218 LBL 30 TO LBL 36 FLOORBEAM CORRODED. REMOVED CORRODED FLOOR SUPPORT. FABRICATED NEW FLOORBEAM. INSTALLED NEW FLOORBEAM. (M)

Part: DOOR FRAME — CORRODED (FUSELAGE)

FTW - FOUND CORROSION ON JAMB BEAM BETWEEN FS 636-693 AROUND RIVETS AND DRILLED OFF SCREWS. FABRICATED 15 DOUBLER AND 9 SPACER. INSTALLED DOUBLER AND SPACER. (M)

Part: FLOOR SUPPORT — CORRODED (FUSELAGE)

FTW - FOUND FORWARD CABIN HAS CORROSION AT FLOOR SUPPORT STATION 200 TO STATION 160 LBL 55 INCHES. REMOVED FLOOR SUPPORT. FABRICATED NEW FLOOR SUPPORT. INSTALLED FORWARD CABIN FLOOR SUPPORT. (M)

Part: FITTING — CRACKED (CARGO DOOR)

FTW - FOUND MID PIT DOOR AFT LOWER DOOR PAN AND ATTACH FITTING CRACKED AT DOOR STOP. REMOVED CRACKED FITTING. LOCATED AND DRILLED NEW FITTING. INSTALLED NEW FITTING. (M)

Part: SUPPORT — CORRODED (FUSELAGE)

FTW - FOUND AFT PIT STATION 1170 STRINGER 18L WEB SUPPORT CORRODED. REMOVED SUPPORT. INSTALLED WEB SUPPORT. (M)

Part: FLOORBOARD — DELAMINATED (FUSELAGE)

FTW - FOUND CABIN FLOORBOARD, RIGHT, OUTBOARD STATION 160-200 MISSING EDGE FILLER, PEELING FIBERGLASS. FABRICATED NEW CABIN FLOORBOARD. (M)

Part: ATTACH FITTING — CORRODED (FUSELAGE)

FTW - FOUND AFT PIT LEFT STATION 1250-1271 SUBFLOOR CORRODED AT FLOORBEAM TO FUSELAGE ATTACH FITTING. FOUND THE FUSELAGE ATTACH FITTING AT STATION 1258 OUT OF LIMITS. REMOVED SUBFLOOR STATION 1250-1287. FABRICATED REPLACEMENT SUBFLOOR. LOCATED AND DRILLED REPLACEMENT FUSELAGE ATTACH FITTING. INSTALLED SUBFLOOR. INSTALLED REPLACEMENT FUSELAGE ATTACH FITTING. (M)

Part: WEB — CRACKED (FUSELAGE)

FTW - FOUND AFT PIT RIGHT STATION 1221-1287 SUB FLOOR WEB CRACKED. FABRICATED WEB. INSTALLED WEB. (M)

Part: FLOORBOARD — DAMAGED (FUSELAGE)

FTW - FOUND CABIN CENTER FLOORBOARD STATION 200-256, MISSING INSERTS, EDGE FILLER MISSING, PEELING FIBERGLASS. FABRICATED NEW CABIN CENTER FLOORBOARD. (M)

Part: FLOORBOARD — DELAMINATED (FUSELAGE)

FTW FOUND CABIN FLOORBOARD, RIGHT INBOARD STATION 180-200 SEVERAL INSERTS MISSING. PEELING FIBERGLASS REQUIRES EDGE FILLER. FABRICATED NEW CABIN FLOORBOARD. (M)

Part: SEAT TRACK — CORRODED (FUSELAGE)

FTW - FOUND CORROSION AND GOUGES ON SEAT TRACK STATION 788 TO 1309 RBL 24. REMOVED SEAT TRACK DAMAGED STATION 927 TO 1309. FABRICATED SEAT TRACK SPLICES. INSTALLED SEAT TRACK. (M)

Part: SEAT TRACK — CORRODED (FUSELAGE)

FTW - FOUND CORROSION AND GOUGES ON SEAT TRACK STATION 788 TO 1309 RBL 44. REMOVED OUT OF LIMIT SEAT TRACK. FABRICATED REPLACEMENT SEAT TRACK. INSTALLED SEAT TRACK. (M)

Part: FLOORBOARD — PEELING (FUSELAGE)

FTW - FOUND CABIN FLOORBOARD LEFT OUTBOARD STATION 160-200 MISSING EDGE FILLER, PEELING FIBERGLASS. FABRICATED NEW CENTER CABIN FLOORBOARD. (M)

Part: FLOORBOARD — DAMAGED (FUSELAGE)

FTW - FOUND CABIN FLOORBOARD, RIGHT STATION 197-229, DAMAGED INSERTS, MISSING EDGE FILLER, PEELING FIBERGLASS. FABRICATED NEW FLOORBOARD. (M)

Part: FLOORBOARD — DAMAGED (FUSELAGE)

FTW - FOUND RIGHT CABIN FLOORBOARD STATION 200-256 MISSING FASTENERS NEEDS EDGE FILLER PEELING FIBERGLASS. FABRICATED NEW RIGHT CABIN FLOORBOARD. (M)

Part: SEAT TRACK — CORRODED (FUSELAGE)

FTW - FOUND FORWARD CABIN STATION 220-200 RIGHT SIDE INBOARD SEAT TRACK HAS GOUGED, NICKS, BARE METAL, LIGHT CORROSION. REMOVED DAMAGED SEAT TRACK STATION 200-265. LOCATED AND DRILLED SEAT TRACK. INSTALLED FASTENERS IN SEAT TRACK AT STATION 200-265. (M)

Part: WEB — CRACKED (FUSELAGE)

FTW - FOUND AFT LEFT STATION 1221-1287 SUB FLOOR WEB CRACKED. SUBFLOOR STATION 1221-1287, REMOVED AND REPLACED. (M)

Part: FRAME — CRACKED (FUSELAGE)

FTW - FOUND NLG WHEEL WELL CUTOUT AFT FRAME CORRODED AND CRACKED AT DOOR LANDING. REMOVED NLG WHEEL WELL AFT FRAME. LOCATED AND DRILLED NEW AFT FRAME. INSTALLED NEW AFT FRAME. (M)

Part: FLOORBOARD — PEELING (FUSELAGE)

FTW - FOUND CABIN FLOORBOARD ENTRY WAY STATION 160-200 EXPOSED HONEYCOMB ON UPPER FACE, PEELING FIBERGLASS. FABRICATED NEW CABIN FLOORBOARD. (M)

Part: SKIN — CORRODED (LT WING)

FTW - FOUND LEFT WING LOWER SKIN PANEL UPPER SURFACE HAS 4 INCH BY 5 INCH DIAMETER EXFOLIATION AT XCW 121 9 INCHES AFT OF WING REAR SPAR AND 9 INCHES MLG TRUNNION FITTING. WING SKIN FSXCW 121 OUTBOARD OF TRUNNION FOUND OUT OF LIMITS. ALT SPAR FS XCW 121 FORWARD BRACKET FOUND TO BE CRACKED. REMVOED BRACKET. FABRICATED NEW ANGLE. LOCATED AND DRILL NEW REPAIR DOUBLER. INSTALL REPAIR DOUBLER. INSTALLED NEW ANGLE. WORK WAS ACCOMPLISHED PER SPIRIT AIRLINE EA 5730-0401. (M)

Part: SEAT TRACK — GOUGED (FUSELAGE)

FTW - FORWARD CABIN STATION 218 TO STATION 200 LEFT INBOARD SEAT TRACK HAS NICKS, GOUGED, CORROSION. REMOVED DAMAGED SEAT TRACK STATION 200-645. DRILLED AND LOCATED NEW TRACK AND SPLICES. INSTALLED SEAT TRACK LBL 24 STATION 200-645 AND 4 EACH SPLICE. (M)

Part: SEAT TRACK — CORRODED (FUSELAGE)

FTW - FOUND CORROSION ON SEAT TRACK STATION 788 TO 1309 LBL 24. REMOVED SEAT TRACK FROM LBL 24 STATION 936 TO 1309. FABRICATED SEAT TRACK. INSTALLED SEAT TRACK. (M)

Part: SEAT TRACK — CORRODED (FUSELAGE)

FTW - FOUND CORROSION AND GOUGES ON SEAT TRACK STATION 788 TO 1309 LBL 44. CUT OUT SEAT TRACK SECTION FROM STATION 1106-1309. LOCATED AND DRILLED TWO SECTION OF SEAT TRACK FROM STATION 1106-1183. LOCATED AND DRILLED TWO SEAT TRACK SPLICES. INSTALLED SEAT TRACK. (M)

Part: FLOORBOARD — CRACKED (COCKPIT)

FTW - FOUND FLT COMP, FLOORBOARD DIRECTLY BEHIND CAPTAINS SEAT IS CRACKED. CUT OUT DAMAGE. FABRICATED DOUBLER AND FILLER. INSTALLED DOUBLER AND FILLER. UPON FURTHER INVESTIGATION FOUND FIBERGLASS DOUBLERS SEPERATE. RECEMENTED FIBERGLASS DOUBLERS. (M)

Part: FLOOR PANEL — CORRODED (COCKPIT)

GTIA - FOUND COCKPIT FLOOR PANEL 4411C CORRODED, CRACKED. BONDED CRACKED AREA. (M)

Part: INDICATOR — STICKING (STAB TRIM)

STAB TRIM INDICATOR ON PEDESTAL STICKS WHEN MOVING. UNSCHEDULED CHANGE OF A/C EN ROUTE. (M)

Part: INTERPHONE — SHORTED (CABIN)

CALL SYSTEM C/B POPS WHEN ANY CALL BUTTON PRESSED. UNSCHEDULED CHANGE OF A/C EN ROUTE. (M)

Part: SLIDE — DISLODGED (PAX DOOR)

FLL - FLT 765 - L1 SLIDE PACK FELL OFF. RE-INSTALLED L1 SLIDE PACK. (M)

Part: WIRE — BROKEN (EMERGENCY LIGHT)

MCO - AFT AIRSTAIR EMERGENCY LIGHT INOPERATIVE. FOUND BROKEN WIRE AT EMERGENCY LIGHT TERMINAL END. REPLACED TERMINAL END. EMERGENCY LIGHT GROUND OPS CHECKS GOOD. (M)

Part: SCHRADER VALVE — LEAKING (MLG)

DTW - FLT 1691 - WHEN LANDING GEAR RAISED AFTER TAKEOFF THE NOSE GEAR LIGHT REMAINED RED. RECYCLED ONCE WITH NO LUCK TRIED ONCE MORE AFTER ABOUT 15 MINUTES TO SEE IF ICE MIGHT HAVE CLEARED, WORKED OK. FOUND NOSE STRUT DOWN TO .5 INCH CHROME, FOUND SCHRADER VALVE LEAKING. SERVICED NOSE STRUT IAW MM 32-21-02. INSTALLED NEW SCHRADER VALVE. LEAK CHECKS GOOD. NO OTHR DEFECTS NOTED. (M)

Part: CONNECTOR — LOOSE (LIGHT)

FTW - FOUND CEILING EMERGENCY LIGHT INOPERATIVE AT ROW 14. FOUND DEFECTIVE TERMINAL CONNECTION. REPAIRED TERMINAL. (M)

Part: CONNECTOR — LOOSE (EXIT SIGN)

FTW - FOUND L1 DOOR EXIT MARKER INOPERATIVE. RESOLDERED CONNECTION ON L1 EXIT IDENTIFIER. (M)

Part: SIGN — CHAFED (CABIN)

FTW - FOUND RIGHT OVERWING EXIT IDENTIFIERS, BOTH FORWARD AND AFT ARE INOPERATIVE. REMOVED RIGHT FORWARD AND SFT EXIT IDENTIFIERS. RESOLDERED CONNECTIONS ON FORWARD AND AFT EXIT IDENTIFIERS. (M)

Part: LINE — LOOSE (FUEL SYSTEM)

FTW - FOUND FUEL IN AFT CARGO PIT AT STATION 1320 LEFT. FOUND ENGINE FUEL FEED LINE AFT SHROUD TO HAVE A LOOSE CONNECTION AND A BROKEN O-RING. REPLACED O-RING AND CONNECTED FUEL LINE. (M)

Part: STRAP — CORRODED (FUSELAGE)

FTW - FOUND AFT PIT STATION 1212 HAS CORROSION AT THE STRAP. REMOVED STRAP. LOCATED NEW STRAP. INSTALLED NEW STRAP. (M)

Part: LONGERON — CRACKED (FUSELAGE)

FTW - FOUND AT FS 236 6L LONGERON CRACKED. REMOVED LONGERON SPLICER AND DAMAGED LONGERON. FABRICATED NEW LONGERON SECTION AND REPAIR SPLICE. INSTALLED NEW LONGERON AND SPLICES. (M)

Part: DOUBLER — DAMAGED (FUSELAGE)

FTW - FOUND EXISTING REPAIR AT FORWARD VHF ANTENNA CUT OUT REQUIRES REPLACEMENT. REMOVED EXISTING REPAIR DOUBLER. FABRICATED DOUBLER AND FILLER. INSTALLED REPAIR DOUBLER AND FILLER. (M)

Part: SKIN — DENTED (FUSELAGE)

FTW - FOUND DENT AT FS 223 BETWEEN LONGERON 15L AND 16L REQUIRES REPAIR. REWORKED DENT. FABRICATED INTERNAL REPAIR DOUBLER. INSTALLED DOUBLER. (M)

Part: FLOORBEAM — CORRODED (FUSELAGE)

FTW - FOUND FLOORBEAM WEB SUPPORT CORRODED STATION 1309 L23L. FABRICATED REPAIR PART. FABRICATED PART AND REINSTALLED. (M)

Part: SKIN — DENTED (FUSELAGE)

FTW - FOUND DENT ON FUSELAGE SKIN STATION 20 LONGERON 13L. DENT AND GOUED OUT OF LIMITS. FABRICATED REPAIR PARTS. INSTALLED REPAIR PARTS. (M)

Part: SKIN — DENTED (FUSELAGE)

FTW - FOUND DENT FS 236 BETWEEN LONGERONS 6L AND 7L REQUIRES REPAIR. REWORKED DENT. FABRICATED REPAIR DOUBLER. INSTALLED REPAIR DOUBLER. (M)

Part: SKIN — DENTED (FUSELAGE)

FTW - FOUND DENT AT FS 640 BETWEEN LONGERONS 15R AND 16R REQUIRES REPAIR. FABRICATED DOUBLER AND FILLER. INSTALLED REPAIR DOUBLER AND FILLER. (M)

Part: DOUBLER — DAMAGED (FUSELAGE)

FTW - FOUND EXISTING REPAIR AT FS 237 BETWEEN LONGERON 30 AND 29L REQUIRES REPLACEMENT. REMOVED EXISTING FILLER AND DOUBLER. FABRICATED NEW DOUBLER AND FILLER. INSTALLED NEW REPAIR DOUBLER AND FILLER. (M)

Part: SKIN — DENTED (FUSELAGE)

FTW - FOUND DENT AT FS 655 BETWEEN LONGERONS 14R AND 15R REQUIRES REPAIR. FABRICATED REPAIR DOUBLER. INSTALLED REPAIR PLUG AND REPAIR DOUBLER. (M)

Part: WEB — CRACKED (FUSELAGE)

FTW - SUBFLOOR AT STATION LBL 26 TO LBL 56 STATION 200-219 HAS 2 CRACKS. DRILLED AND LOCATED FLOOR WEB. (M)

Part: LONGERON — CRACKED (FUSELAGE)

FTW - FOUND E/E BAY LONGERON 24L AT STATION 200 HAS EXFOLIATION/CRACK WHERE CAP IS FASTENED TO LONGERON. REMOVED DAMAGED SECTION OF LONGERON. LOCATED AND DRILLED NEW LONGERON AND LONGERON SPLICE. INSTALLED LONGERON AND SPLICES. (M)

Part: FITTING — CORRODED (FUSELAGE)

FTW - FOUND LONGERON END FITTING 29R STATION 1338 HAS CORROSION AROUND FASTENERS ON FITTING. MATERIAL LOSS FOUNDED OUT OF LIMITS. REMOVED FITTINGS. INSTALLED NEW FITTING 29R. (M)

Part: FITTING — CORRODED (FUSELAGE)

FTW - FOUND LONGERON END FITTING 29L HAS CORROSION AROUND FASTENERS ON FITTING. MATERIAL LOSS FOUNDED OUT LIMITS. REMOVED FITTING. INSTALLED NEW FITTING. (M)

Part: LONGERON — CRACKED (FUSELAGE)

FTW - FOUND LONGERON 25L AT STATION 160 IN E/E COMPARTMENT IS CRACKED. REMOVED DAMAGED SECTION OF LONGERON. LOCATED AND DRILLED LONGERON SPLICE. INSTALLED LONGERON AND SPLICES. (M)

Part: FLOOR SUPPORT — CORRODED (FUSELAGE)

FTW - FOUND AFTER REMOVAL OF THRESHOLD TO FOM FLOOR SUPPORT WAS FOUND TO BE EXFOLIATED AT STATION 190, APPROX LBL 54 APPROX. REMOVED FLOOR SUPPORT. DRILLED AND LOCATED THE ANGLE SUPPORT. INSTALLED FLOOR SUPPORT. (M)

Part: ISOLATOR — DAMAGED (RT ENGINE)

FTW - FOUND RIGHT ENGINE FORWARD LOWER VIBRATION ISOLATOR INNER CORE ASSEMBLY CONTACTING OUTER RETAINER AND SLIPPAGE MARKS MORE THEN .5 INCH. REMOVED RIGHT ENGINE FORWARD LOWER VIBRATION ISOLATOR INNER CORE ASSEMBLY. INSTALLED RIGHT LOWER VIBRATION ISOLATOR. (M)

Part: FLOOR SUPPORT — CORRODED (FUSELAGE)

FTW - FOUND FORWARD CARGO FS 427 FLOOR SUPPORT CORRODED AND DOUBLE DRILLED STATION 29R-28R. REMOVED FLOOR SUPPORT STATION 427 RBL 29 TO LBL 28. FABRICATED NEW SUPPORT. INSTALLED SUPPORT. (M)

Part: STRUCTURE — CORRODED (FUSELAGE)

FTW - FOUND AFTER REMOVAL OF THRESHOLD TO FOM ENTRY WAY SUB FLOOR WAS FOUND CORRODED AT APPROX STATION 200. REMOVED CORRODED SECTION SUBFLOOR. FABRICATED REPAIR SPLICE. INSTALLED SPLICE, FLOOR SUPPORT AND WEB. (M)

Part: FLOOR SUPPORT — CORRODED (FUSELAGE)

FTW - FOUND FORWARD CARGO FS 427 FLOOR SUPPORT CORRODED AND DOUBLER DRILLED STATION 29R-29L. REMOVED DAMAGED FLOOR SUPPORT. LOCATED AND DRILLED NEW PART. INSTALLED NEW FLOOR SUPPORT. (M)

Part: FITTING — CRACKED (CARGO DOOR)

FTW - FOUND AFT PIT STATION 1155 L25R-L26R DOOR LATCH FITTING ON FORWARD DOOR FRAME IS CRACKED. REMOVED OLD DOOR LATCH FITTING FROM FRAME DRILLED NEW DOOR LATCH. INSTALLED DOOR LATCH FITTING. (M)

Part: FRAME — CORRODED (FUSELAGE)

FTW - AFT PIT STATION 1309 L30-L23L, AREAS OF CORROSION ON FORWARD AND AFT SIDES OF FRAME. REMOVED SECTION OF DAMAGE. LOCATED AND DRILLED NEW FRAME SECTION. INSTALLED FRAME. (M)

Part: ATTACH ANGLE — CORRODED (FUSELAGE)

FTW - FOUND MID CARGO FORWARD BULKHEAD LOWER ATTACH ANGLE CORRODED FS 541 LBL 15 INCHES TO RBL 15 INCHES. REMOVED ATTACH ANGLE. FABRICATED A NEW SUPPORT ANGLE. INSTALLED SUPPORT ANGLE. (M)

Part: ANGLE — CRACKED (FUSELAGE)

FTW - BELT FRAME LOWER ATTACH ANGLE CRACKED FS 529 STATION 28L AND 27L. CUT OUT CRACKED ATTACH ANGLE. FABRICATED REPAIR. INSTALLED REPAIR. (M)

Part: DOUBLER — CRACKED (FUSELAGE)

FTW - FOUND FORWARD CARGO FS 263 STATION 23L-24L PREVIOUS REPAIR HAS CRACKS ON DOUBLER. REMOVED EXISTING DOUBLER, SPLICES AND STRAP. FABRICATED DOUBLER, SPLICES AND STRAP. INSTALLED NEW DOUBLER, SPLICES AND STRAPS. (M)

Part: BEAM — CORRODED (FUSELAGE)

FTW - FOUND AFT PIT STATION 1155-1212 L28R, REPAIR STRAP ON DOOR JAMB BEAM IS CORRODED. REMOVED CORROSION AND INTERCOSTAL. FABRICATED INTERCOSTAL AND ANGLES. INSTALLED CLIPS BRACKETS, ANGLES AND NEW INTERCOSTAL. (M)

Part: DOUBLER — CORRODED (FUSELAGE)

FTW - ANTENNA INNER DOUBLER CORRODED FS 675 TO 685 STRINGER 29R TO 27L. REMOVED ANTENNA DOUBLER. LOCATED AND DRILLED NEW ANTENNA DOUBLER. INSTALLED DOUBLER. (M)

Part: INTERCOSTAL — CORRODED (FUSELAGE)

FTW - FOUND AFT PIT STATION 1212 L28R-L29R, INTERCOSTAL CORRODED. REMOVED INTERCOSTAL AND SUPPORT ANGLES. FABRICATED NEW INTERCOSTAL. INSTALLED INTERCOSTAL. (M)

Part: BEAM — CORRODED (FUSELAGE)

FTW - FOUND CARGO DOOR JAMB BEAM CORRODED FS 636 TO 693. REMOVED JAMB BEAM MID CARGO DOOR AND BRACKETS. FABRICATED BRACKETS AND CENTER BACK. LOCATED AND DRILLED NEW JAMB BEAM. INSTALLED JAMB BEAMS MID CARGO DOOR AND CORNER BRACKET. (M)

Part: INTERCOSTAL — CORRODED (FUSELAGE)

FTW - FOUND AFT PIT STATION 1322-1338 L226, LOWER FLANGE OF INTERCOSTAL IS CORRODED AROUND ATTACH FASTENERS. REMOVED INTERCOSTAL. FORMED INTERCOSTAL. INSTALLED INTERCOSTAL. (M)

Part: SPLICE — CORRODED (FUSELAGE)

FTW - FOUND STRINGER 30 SPLICE FITTING CORRODED FS 579-595. DUPLICATED LONGERON SPLICE. SPLICES FS 579-FS 595 TO BE INSTALLED ON WC B00038 118 N 00108. (M)

Part: INTERCOSTAL — CORRODED (FUSELAGE)

FTW - FOUND AFT PIT STATION 1212-1220 BETWEEN L29R-L30, INTERCOSTAL IS CORRODED. REMOVED DAMAGED PARTS. FORMED PARTS. INSTALLED PARTS. (M)

Part: SKIN — CORRODED (FUSELAGE)

FTW - FUSELAGE INNER SKIN CORRODED FS 788 STRINGER 28L TO 28R. REMOVED LONGERON 30. REMOVED CORROSION ON LONGER 30 AND DAMAGED SKIN. LOCATED AND DRILLED NEW LONGERON 30. FABRICATED FILLERS, REPAIR DOUBLER, REPAIR TRIPLER AND REPAIR SECTION OF FORMER. INSTALLED FILLERS, DOUBLERS, TRIPLERS, SECTION OF FORMER AND SPLICE. (M)

Part: DOUBLER — CORRODED (FUSELAGE)

FTW - FOUND ANTENNA INNER DOUBLER CORRODED. REMOVED ANTENNA DOUBLER. LOCATED AND DRILLED ANTENNA DOUBLER. INSTALLED DOUBLER. (M)

Part: FLOOR SUPPORT — CORRODED (FUSELAGE)

FTW - AFT PIT STATION 1155-1212 L29R, THRESHOLD/FLOORBOARD SUPPORT HAS AREAS OF BARE METAL/LT CORROSION. REMOVED FLOOR SUPPORT. INSTALLED NEW FLOOR BOARD SUPPORT. (M)

Part: PANEL — CORRODED (WING)

FTW - FOUND PANEL 1220C, EXFOLIATION CORROSION NEAR CORNER, SEVERAL OXIDIZED SCREW HOLES AND HEADS. MATERIAL LOSS OUT OF LIMITS. REPAIR DOUBLER FABRICATED. INSTALLED REPAIR DOUBLER. (M)

Part: ANGLE — CORRODED (FUSELAGE)

FTW - FOUND AFT PIT STATION 1155 CORNER ANGLE, DOOR FRAME TO SKIN, IS CORRODED. REMOVED CORNER ANGLE. DRILLED AND LOCATED NEW ANGLE. INSTALLED NEW ANGLE. (M)

Part: ANGLE — CORRODED (FUSELAGE)

FTW - AFT PIT STATION 1212 CORNER ANGLE, DOOR FRAME TO SKIN, IS CORRODED. REMOVED CORNER ANGLE. DRILLED AND LOCATED NEW ANGLE. INSTALLED NEW ANGLE. (M)

Part: INTERCOSTAL — CORRODED (FS 1202)

FTW - FOUND AFT PIT STATION 1212 L28R-L29R, INTERCOSTAL CORRODED. REMOVED INTERCOSTAL AND SUPPORT ANGLES. FABRICATED NEW INTERCOSTAL. INSTALLED INTERCOSTAL. (M)

Part: STRINGER — CORRODED (FUSELAGE)

FTW - FOUND STRINGER 30 CORRODED FS 617 TO 610, FS 617-636, 636-655, 674-655. FOUND TO BE OUT OF LIMITS. REMOVED LONGERON REPAIR STATION. FABRICATED LONGERON SPLICES AND REPAIR STATION. INSTALLED LONGERON 30 AND SPLICES REPAIR. (M)

Part: WEB — CORRODED (FUSELAGE)

FTW - FOUND PIT STATION 1148-1220 L27R-L29R, THRESHOLD CLOSURE WEB HAS AREAS OF CORROSION ON UPPER AND LOWER SURFACES. REMOVED WEB. FABRICATED NEW WEB. INSTALLED WEB. (M)

Part: INTERCOSTAL — CORRODED (FUSELAGE)

FTW - FOUND AFT PIT STATION 1193 L28R-L29R, INTERCOSTAL CORRODED. REMOVED INTERCOSTAL AND SUPPORT ANGLES. FABRICATED INTERCOSTAL. INSTALLED INTERCOSTAL. (M)

Part: PANEL — DAMAGED (WING)

FTW - FOUND PANEL 1171C BARE METAL ON BACK SIDE, NUMEROUS OXIDIZED SCREW HEADS AND SCREW HOLES, EXFOLIATION CORROSION IN TWO PLACES. FOUND MATERIAL TO BE OUT OF LIMITS IN 2 PLACES. FABRICATED TWO DOUBLERS. INSTALLED TWO DOUBLERS. (M)

Part: PANEL — DENTED (WING)

FTW - FOUND PANEL 1120C HAS A DENT, BARE METAL. DENT OUT OF LIMITS. FABRICATED DOUBLER. INSTALLED REPAIR DOUBLER. (M)

Part: SKIN — DELAMINATED (RT AILERON)

FTW - FOUND RIGHT OUTBOARD AILERON TAB DELAMINATED ON LOWER SURFACE AT INBOARD END AND AT CENTER HINGE. REMOVED RIGHT AILERON OUTBOARD TAB. DAMAGE EXCEEDS MD80 SRM REPAIR LIMITS. INSTALLED RIGHT OUTBOARD AILERON TAB. (M)

Part: STRUCTURE — CORRODED (ELEVATOR TAB)

FTW - FOUND RIGHT ELEVATOR ANTI-FLOAT TAB LOWER SURFACE LE HAS CORROSIN FROM INBOARD SIDE TO OUTBOARD SIDE. MATERIAL LOSS FOUND TO BE OUT OF LIMITS. REMOVED RIGHT ELEVATOR ANTI-FLOAT TAB. INSTALLED RIGHT ELEVATOR ANTI-FLOAT TAB. (M)

Part: SKIN — DAMAGED (TE FLAP)

FTW - FOUND LEFT FLAP UNDERSIDE HAS METAL FILLER FALLING OUT. REMOVED DAMAGED SKIN. MATERIAL SUBSTITUTED FROM 2014-T6 TO 7075-T6. FABRICATED REPAIR DOUBLER AND FILLER. INSTALLED REPAIR DOUBLER AND FILLER. (M)

Part: SKIN — DELAMINATED (LT ELEVATOR TAB)

FTW - FOUND LEFT ELEVATOR GEAR TAB DELAMINATED LOWER SURFACE AT 1/B AND OUTBOARD SIDES. REMOVED GEARED TAB. REPAIRED LEFT ELEVATOR GEARED TAB. INSTALLED GEARED TAB ON LEFT ELEVATOR. (M)

Part: SKIN — DELAMINATED (RT ELEVATOR TAB)

FTW - FOUND RT ELEVATOR CONTROL TAB IS DELAMINATED UPPER LOWER. REMVOED RIGHT ELEVATOR CONTROL TAB. TAB HAS CORROSION DAMAGE TO FRONT. REPLACED CONTROL TAB. INSTALLED RIGHT ELEVATOR CONTROL TAB. (M0

Part: SKIN — DELAMINATED (ELEVATOR TAB)

FTW - FOUND LEFT ELEVATOR CONTROL TAB UPPER SURFACE DELAMINATED AT 2/3 HINGE FITTINGS. REMOVED LEFT ELEVATOR CONTROL TAB. REPAIRED LEFT ELEVATOR CONTROL TAB. INSTALLED LEFT ELEVATOR TAB. (M)

Part: SKIN — DAMAGED (NR 5 SLAT)

FTW - RIGHT LEADING EDGE SLAT NR 5 DAMAGED TO APPROX 6 INCHES FROM OUTBOARD TIP, TEMPORARY REPAIR INSTALLED. REMOVED RIGHT LE NR 5 SLAT. REMOVED INNER SKIN AND CRACKED RIB. FORMED NEW RIB. INSTALLED RIB AND INNER SKIN. (M)

Part: SKIN — DENTED (CARGO DOOR)

FTW - THREE DENTS UNDER AFT CARGO DOOR LOWER FUSELAGE TWO DENTS APPROX 4 INCHES LONG BY .125 INCHES DEEP 1 DENT APPROX 3 INCHES LONG BY .125 INCHE DEEP. REMOVED DAMAGE AREA. FABRICATED OF THE 3, 5, 7, 9, 11, 13 AND 15. INSTALLED REPAIR PART. (M)

Part: THRUST REVERSER — DENTED (NR 1 ENGINE)

FTW - FOUND THREE DENTS ON FORWARD PART OF LOWER T/R 1 ENGINE. FABRICATED REPAIR DOUBLER. INSTALLED REPAIR DOUBLER. (M)

Part: SKIN — DELAMINATED (T/E FLAP)

ACY - RIGHT FLAP TRAILING EDGE HAS DELAMINATION AND SEPARATION ON OUTBOARD. REPAIRED DELAMINATION OF RIGHT OUTBOARD FLAP TRAILING EDGE BY STOP DRILLING CRACK AND FILLING AREA WITH PR1422 B1/2 SEALANT IAW SRM 57-03. (M)

Part: SKIN — DELAMINATED (T/E FLAP)

ACY - LEFT FLAP HAS DELAMINATION AND SEPARATION ON OUTBOARD SIDE. REPAIRED DELAMINATION ON LEFT FLAP TRAILING EDGE BY STOP DRILLING CRACK AND FILLING AREA WITH PR1422 B HALF SEALANT IAW DC9/MD 80 SRM 57-03. (M)

Part: DEFLECTOR — CRACKED (NLG)

FTW - FOUND RIGHT SIDE OF NOSE GEAR SPRAY DEFLECTOR CRACKED. REPLACED RIGHT SIDE OF NOSE GEAR SPRAY DEFLECTOR. NO DEFECTS NOTED. (M)

Part: SMOKE DETECTOR — FAILED (LAVATORY)

DTW - FOUND AFT RIGHT LAVATORY SMOKE DETECTOR FAILS TO TEST. CLEANED CANNON PLUG, OPS CHECK NORMAL IAW MD80 MM 26-10-00. (M)

Part: CONTROL PANEL — FAILED (CABIN)

DTW - FOUND LIGHT ABOVE AFT TAIL SLIDE INOPERATIVE. REPAIRED GROUND BAR AFT OVERHEAD PANEL EMEGENCY LIGHT, OPS CHECK NORMAL IAW MD 80 MM 33-50-00. (M)

Part: COMPUTER — FAILED (COCKPIT)

RSW - NR 1 DFGS WENT INOPERATIVE ON SHORT FINAL. NR 2 DFGS WORKS OK. REMOVED AND REPLACED NR 1 DIGITAL FLIGHT GUIDANCE COMPUTER AS REQUIRED IAW MD80 MM CH 22-01-05. PERFORMED RETURN TO SERVICE TEST. RTS CHECK GOOD. (M)

Part: DRIVE UNIT — FAULTY (AUTOTHROTTLE SYS)

FLT 1225 - RSW - AUTOTHROTTLES INOPERATIVE, WOULD NOT ENGAGE FOR TAKEOFF, WOULD NOT STAY ENGAGED AT CRUISE. REMOVED AND REPLACED A/T SERVO DRIVE UNIT IAW MD80 MM 22-31-01. OPERATIONAL TEST, OPS OK, RAN RTS TEST ON STP, OPS OK IAW MD80 MM 22-01-05. (M)

Part: DEFLECTOR — CRACKED (NLG)

FLL - RIGHT SIDE SPRAY DEFLECTOR ON NOSE GEAR CRACKED ON TOP APPROX 4 INCH FROM CENTER BOLTS. REMOVED AND REPLACED RIGHT NOSE GEAR SPRAY DEFLECTOR IAW MM 32-20-01. (M)

Part: POWER SUPPLY — DISCHARGED (CABIN)

DTW - FOUND EXTERIOR EMERGENCY LIGHTS STAY ON AT ALL TIMES. REMOVED AND REPLACED EXTERIOR EMERGENCY LIGHTS BATTERY POWER SUPPLY IAW MD80 M/M 33-50-00. OPS CHECK GOOD. (M)

Part: LIGHT — INOPERATIVE (CABIN)

DTW - EMERGENCY FLOOR PATH LIGHTING NOT ILLUMINATING ROWS 23-29. REPAIRED EMERGENCY FLOOR PATH LIGHT AT ROW 23. SYSTEM OPS CHECK GOOD MD80 M/M 33-53-01. (M)

Part: BATTERY PACK — DISCHARGED (A/C BAY)

FLL - EMERGENCY LIGHTS INOPERATIVE IN TAILCONE AREA REF STATION 1152 TO 1237. REMOVED AND REPLACED AFT BATTERY PACKS ASSEMBLIES (85-27 AND B5-28). RELAMPED SEVERAL LIGHTS. FOUND WIRE L794E10 GROUNDED TO FRAME AT TERMINAL STRIP 53-179. REPOSITIONED WIRE AS PER MM 33-51-01. EMERGENCY LIGHTS, OPS NORMAL AS PER MM 33-51-01. (M)

Part: CONNECTOR — LOOSE (CABIN)

DTW - AFT OVERWING LEFT AND RIGHT EMERGENCY EXIT LIGHT INOPERATIVE. RESEATED CANNON PLUG AT BATTERY PACK, OPS CHECK GOOD ON EMERGENCY PATH LIGHTING PER MD80 MM 33-53-00. NO OTHER DISCREPANCIES NOTED. (M)

Part: BATTERY PACK — DISCHARGED (TAIL CONE)

DTW - OVERHEAD EMERGENCY LIGHTS IN TAILCONE INOPERATIVE. REMOVED AND REPLACED BATTERY PACK, OPS CHECK GOOD IAW MD80 MM 33-51-00. (M)

Part: SMOKE DETECTOR — FAULTY (CARGO BAY)

RSW - CARGO DETECTION LOOP LIGHT ANNUNCIATOR ACCOMP BY SMOKE DETECTOR LOOP ILLUMINATED AT START FORWARD PIT. REMOVED AND REPLACED FORWARD 'A' LOOP SMOKE DETECTOR. OPS CHECK GOOD. (M)

Part: SWITCH — INOPERATIVE (COCKPIT)

A/P WILL NOT ENGAGE APPEARS TO BE PROBLEM WITH F/O'S A/P CONTROL WHEEL DISENGAGE SW NOT FUNCTIONING PROPERLY. REMOVED AND REPLACED F/O SWITCH FOR AUTO PILOT. (M)

Part: BATTERY PACK — DISCHARGED (CABIN)

DTW - FLT 594 - CEILING EMERGENCY STANDBY LIGHTS ARE OUT ABOVE ROWS 7, 16, 17, 18, 19, 20, 27, 32. REMOVED AND REPLACED EMERGENCY LIGHT BATTERY PACK T STATION 671 IAW MD80 MM 33-53-01. SYSTEM OPS CHECK GOOD. (M)

Part: COMPUTER — FAULTY (NR 2)

FLL - FLT 941 - ON NR 2, DFGS AUTOPILOT KICKED OFF SEVERAL TIMES IN CLIMB NR 1 WAS FINE. REMOVED AND REPLACED NR 2 DFGC IAW MM 22-01-01. PERFORMED RTS REF MM 22-01-05. (M)

Part: BATTERY — DISCHARGED (A/C BAY)

FLL - FLT 779 - TAIL COMPARTMENT EMERGENCY LIGHTS INOPERATIVE. REPLACED BATTERIES FOR TAIL COMPARTMENT EMERGENCY LIGHTS. OPS CHECK NORMAL IAW MM 33-50-00 AND 33-53-01. (M)

Part: LIGHT — INOPERATIVE (A/C BAY)

FLL - FLT 171 - TAIL COMP EMERGENCY LIGHTS INOPERATIVE. REMOVED AND REPLACED BULB IN TAIL FOR EMERGENCY LIGHTS IAW MM CHAPTER 33-53-00. OPS CHECK GOOD. (M)